Please forgive me for not searching this all out but I could not find it all in the owners manual and I am watching both kids tonight so my "Search" time was limited.


Engine Oil, confirm 10 quarts please


Allison Tranny, 22 quarts with filter? damn http://www.dieselplace.com/forum/smileys/Dead.gif


Transfer case, ??? no clue. Type fluid and how much please.


I am going to have my first maintenance session with my rig (48,500, used) 2003 model tomorrow and I need to know what to buy at the Auto Bone.





Thanks!

Grog


10 is correct on engine oil, but you will not get 22 out of the tranny unless you do a flush (look at Hoot how to do a complete change) it works. don't know about the transfer case cause Im a 2wd. Hope this helps.


Genohttp://www.dieselplace.com/forum/smileys/Hug.gif

Two Quarts on the T-case,same as tranny fluid specs.





Mac

Not planning on flushing the tranny.....just a drain and filter. 20-21 then?


OK, 2 quarts in the Tcase.....same stuff as the auto tranny?

If your just draining the stock pan about 7.5 quarts the deep pan adds little over 3 additional quarts.


The T-case takes the same fluid.





Mac

How can I tell if I have the deep pan?

How can I tell if I have the deep pan?








It doesen't come stock with one. Some have changed after purchase.


Did you buy it new? Then it has a shallow pan.





Mac

Shallow pan then, thanks a million...

wonrog: change your fuel filter and pray it has been done before 48500 miles. This is real important. Also rear end fluid takes 4 quarts, many come through with a little over 2 quarts in them. Just thought I would bring these items up, I guess you should do it all while your at it.

Yep, do your front and rear diff. JMO but I would run syn atf in the transfer case, 2 quarts so its cheap. mobil 1 is what I use. syn 75 90 weight front and rear.


regular dino dex 3 in the trans.


Dont forget the doughnut magnet on the ally spin on filter.