 |
|
 |
 |
        |
 |
|
|||||||
| Register | FAQ | Forum Rules | Calendar | My Replies | My Threads | Mark Forums Read | Auto Escrow | Auto Loans |
 |
|
|
LinkBack | Thread Tools |
01-25-2013, 07:12 PM
|
#1 (permalink) |
|
Diesel Fanatic
 Join Date: Feb 2012
Location: Lethbridge Alberta Canada
Posts: 58
iTrader Score: 0 reviews
Alberta Coal Rollers Member |
No glow
hi all
recently installed my new glow plug harness. work fine however today i noticed when i hop in the truck and turn the key on i have no glow plug light. bulb and fuse in cab are good. any ideas!! Scott
__________________
1994 GMC K2500 6.5turbo Diesel mostly stock. re-located PMD 3inch turbo back, no kittys, straight piped HID conversion 399998KMS 6.5L rebuild manual http://www.skylab.org/~zetan/van/9-2815-237-34.pdf |
| Offline |
Tweet
-->
|
| Sponsored Links | |||
Advertisement | |||
|
01-25-2013, 07:26 PM
|
#2 (permalink) |
|
Diesel Master
Join Date: Oct 2009
Posts: 1,663
iTrader Score: 0 reviews
|
Check all the fuses, not sure about 94's my 95 has a fuse under the hood that runs the fuel heater, when that shorted it blew that fuse & I had no glows or boost
__________________
1995 1500 Silverado 6.5L 2WD Ext Cab 230K, FSD cooler bumper mount, Buddy 3 pos chip, DE 4" exhaust, K47 with F intake 1995 Tahoe Buddy chipped cat & muff delete 202K 1996 TDI Passat 180K 49mpg avg 2005 bagger 107", Fueling 574 cams, 10.1 CR, Mik 45 carb, SE timing map, 3.37 final, Energy1 clutch & VPC plate with SE 6 sp, SnS roller rockers Bub 7 2 into 1 exhaust, 124 Tq & 120Hp 1995 FXD Superglide, Mikuni 42 carb, SE slip ons, V Thunder 2015 cam 80 Tq & 70 Hp
|
| Offline |
|
|
01-25-2013, 07:53 PM
|
#3 (permalink) |
|
Diesel Fanatic
Join Date: Feb 2012
Location: Lethbridge Alberta Canada
Posts: 58
iTrader Score: 0 reviews
Alberta Coal Rollers Member |
i dont seem to see any under the hood fuse boxes to check. I was thinkin on it when i removed the wires off the glow plug controller the red ( hot) wire touched something and sparked could i have poped a relay or somthing somewhere. if so where is it located
thanks
__________________
1994 GMC K2500 6.5turbo Diesel mostly stock. re-located PMD 3inch turbo back, no kittys, straight piped HID conversion 399998KMS 6.5L rebuild manual http://www.skylab.org/~zetan/van/9-2815-237-34.pdf |
| Offline |
|
|
01-25-2013, 08:43 PM
|
#4 (permalink) |
|
Diesel Enthusiast
Join Date: Jan 2013
Location: St.Clements Ontario
Posts: 20
iTrader Score: 0 reviews
|
Fuse panal is in the cab on a 1994 to the left under the steering column.
__________________
1994 Chevrolet K3500 4L80E Pmd relocated in cab on heatsink,#9 resistor,ssdiesel hot air intake,Heath Turbomaster,Diamond eye 4" with 6" tip,Dual relay OPS mod,Fast idle switch. |
| Offline |
|
|
01-25-2013, 08:45 PM
|
#5 (permalink) |
|
Diesel Fanatic
Join Date: Feb 2012
Location: Lethbridge Alberta Canada
Posts: 58
iTrader Score: 0 reviews
Alberta Coal Rollers Member |
if thats the only fuse box in the truck i have located it and ensured the 5amp glow fuse is good. i thinking i will drop in a new glow [plug controller and see what happens
__________________
1994 GMC K2500 6.5turbo Diesel mostly stock. re-located PMD 3inch turbo back, no kittys, straight piped HID conversion 399998KMS 6.5L rebuild manual http://www.skylab.org/~zetan/van/9-2815-237-34.pdf |
| Offline |
|
|
01-25-2013, 11:29 PM
|
#6 (permalink) |
|
Diesel Laureate
Join Date: Feb 2006
Location: Richardson, TX
Posts: 10,411
iTrader Score: 0 reviews
|
Can you start it?
May be just the GPs bulb gone out?
__________________
1995 GMC Suburban: PMD in Bumper 4" Warpspeed Exhaust
KD LP/OPS Harness Bosch Duraterm GP Heath Turbo-Master Chevron's XLP Diesel Additive |
| Offline |
|
|
01-26-2013, 12:33 AM
|
#7 (permalink) |
|
Diesel Fanatic
Join Date: Feb 2012
Location: Lethbridge Alberta Canada
Posts: 58
iTrader Score: 0 reviews
Alberta Coal Rollers Member |
yes i can start it take a bunch of cranks due to the lack of glow plug assistance.checked the bulb and the fuse they appear good
__________________
1994 GMC K2500 6.5turbo Diesel mostly stock. re-located PMD 3inch turbo back, no kittys, straight piped HID conversion 399998KMS 6.5L rebuild manual http://www.skylab.org/~zetan/van/9-2815-237-34.pdf |
| Offline |
|
|
01-26-2013, 11:04 AM
|
#8 (permalink) |
|
Diesel Laureate
Join Date: Feb 2006
Location: Richardson, TX
Posts: 10,411
iTrader Score: 0 reviews
|
Before that you may want to check your new harness installation and see if anything becomes loose after the install.
The other components are the GP controller/relay and the GPs. For GPs, get some Bosch Duraterms. Controller is not picky.
__________________
1995 GMC Suburban: PMD in Bumper 4" Warpspeed Exhaust
KD LP/OPS Harness Bosch Duraterm GP Heath Turbo-Master Chevron's XLP Diesel Additive Last edited by JMJNet; 01-26-2013 at 11:07 AM. |
| Offline |
|
|
01-26-2013, 06:56 PM
|
#9 (permalink) |
|
Diesel Technician
Join Date: Sep 2012
Location: union bridge,md
Posts: 213
iTrader Score: 1 reviews
Old School Oil Burners (Old SOBs) Member |
i found on my 94 that if ecm detects low ohms to ground it wont energize glows.
__________________
94 gmc 1500 with 93 6.5 td auto trans, 4x4, z71,33x12.5 tires, excab 6' bed, 100,000 on motor 266 on truck. No egr F series intake. Has 4" straight pipe exhaust,2.5" crossover pipe, bosch duraterm glowplugs, pmd relocation with #9 res, custom cold air box, oil pres,trans temp, boost, egt glowshift gauges, b&m trans switch, ho water pump with d-maxx fan and duel t-stats. Tcc mod, high idle mod, glowplug mod hid headlights with black out front lights, hx-35 turbo upgrade using factory vac system, bosch injectors popped to 2300psi, buddy 6-stage chip. 95 gmc jimmy with cpi, intake and duel exhaust 2" lift, future 6.2 project- 89 6.2 n/a 90 cavalier stock 2.2 over 234000, replaced cluster from a cimarron 71 mustang, 302 headman headers, msd box and distributor, cobra intake, 650 holley, shift kit, alum rad, mach 1 set up, mag 500 wheels 99 s10 zr2 5spd with 6"lift on 33's, black and white |
| Online |
|
|
01-26-2013, 07:10 PM
|
#10 (permalink) |
|
Diesel Fanatic
Join Date: Feb 2012
Location: Lethbridge Alberta Canada
Posts: 58
iTrader Score: 0 reviews
Alberta Coal Rollers Member |
Great news! turns out i had everything wired correctly. when i put everything back together i over tightened the +lead on the glow plug controller and broke it loose! thanks to everyone who took the time to respond and give me pointers!!
__________________
1994 GMC K2500 6.5turbo Diesel mostly stock. re-located PMD 3inch turbo back, no kittys, straight piped HID conversion 399998KMS 6.5L rebuild manual http://www.skylab.org/~zetan/van/9-2815-237-34.pdf |
| Offline |
|
| Sponsored Links | |
Advertisement | |
| Sponsored Links | |
Advertisement |
|
|
| Thread Tools | |
|
|
Similar Threads
|
||||
| Thread | Thread Starter | Forum | Replies | Last Post |
| LLY: Glow plugs and glow plug module? | DieHardChevyMan | Who sells [fill in the blank]? | 0 | 01-09-2012 09:25 PM |
| glow plug light and glow plugs not coming on | LETR FLY | Electrical | 0 | 02-18-2011 07:15 PM |
| Glow Controller Glow Time / Adjustment | koolky | 6.2L Diesel Engine | 7 | 01-03-2011 08:36 AM |
| Glow plug relay *POPS*...but glow plugs don't light? | zeitgeist57 | 6.2L Diesel Engine | 2 | 06-23-2007 11:37 AM |
| How to make my 1976 No Glow, Glow? | 76chevyc10 | 6.2L Diesel Engine | 6 | 01-17-2007 02:35 PM |
